True Stories

From: Kate Smith
Sent: June-09-11
To: Will Curry
Subject: RE: Hydrovane Report

Good Day Will,

We just completed a trip from Ft. Lauderdale to New York in our Bristol 29.9, and are happy to report that our Hydrovane steered the boat flawlessly. We flew a Code 0 headsail with a full battened mainsail for the entire trip, as the wind speed varied from 5 to 18 knots, close reaching to a dead down wind run. On all points of sail and wind velocities “Hydro” steered a steady course.

This trip verified your suspicion that the initial difficulties we encountered, in using the Hydrovane, was due to our inability to adapt to the set up procedure for the Hydrovane after using a RVG unit for twenty years. You were right, all of our problems were created by operator error. Now that we have exorcised the ghost of the RVG from “Santih”  and her crew the Hydrovane is free to perform to its potential, which exceeds our expectations.

Also, as you predicted the Hydrovane is a much more sophisticated, powerful, and precise unit than the RVG. One additional benefit of the Hydovane is the ability to remove the rudder when we are motoring long distances, and in areas where maneuverability is at a premium. Since our unit is mounted two feet aft of the transom, removing it greatly reduces our turning radius and improves maneuvering in reverse.

I want to thank you for your patience, and the time you have spent instructing me on the use of the Hydrovane. The Hydrovane is an outstanding product, which I unconditionally recommend, but it is the outstanding service that you provide which makes it possible for your customers to realize its potential.

Respectfully,
Steve Smith

From: Barbara & Brian
Sent: May-22-11
Cc: Will Curry
Subject: iVane and armola

Hi again,
I am motivated though by two things: one, our splendid today at sea guided for the first time (any distance that is) by our iVane. We covered about 20 miles in 22 knots of wind with iVane studiously and without fault steering to the wind. We had a couple faults but, as usual, human error put up his hand.

This venture won’t impress you much but for me, even a small passage without a single energy demand… especially MY energy… is a grand gesture to the environment and our peace of mind. I know the vulnerability of electronic auto-pilots.

…
Cordially,
Brine

… and subsequently updated us ….

From: Barbara & Brian
Sent: October-20-11
To: Will Curry
Subject: some more small applause

Hi Will. I wanted to share this small missive from Sicily with you, just because it contains a reference to iVane. Hope life and business are flourishing.

Sincerely,
Brian A.
———————————–

Hi again, this time from the SE coast of Sicily. Once elegant Siracusa town, now looking tired and gritty, a bit sad-sack…but to us, the very finest shelter after our mini-passage of 330 miles (60 hours) from Greece. Knowing me and knowing October, you’ll expect the passage to have some of these “!!” attached to its description.

We sailed about 250 miles of the trip with deeply reefed sails in winds from 15 to 50 knots!! For the first time, we had to run downwind, under bare poles in gale force 8 conditions, with gusts to 50 knots – and don’t get me started on the sea conditions! Have you ever swallowed your tongue? Well then, you know what I mean. Oh, and we had sessions of savage rain, no visibility in the shipping lane and lightning!

We left Pilos with a reasonable forecast (25 knot winds), and if I meet up with the forecaster, I’ll happily smack him with a spade. We did want to avoid having to motor and we knew the early part of the trip might be rough. But not of the disemboweling sort. Going to the head in a seaway is never joyous, but this was like I had a live goat in there with me, he had to go too!!

As an independant measure of things, on Monday noon (we had been at sea only 26 hours) a supertanker did an unusual thing. The gentleman captain altered course, rounded into the wind and stood off about a half mile upwind of us, asking if we needed assistance! I didn’t think he had the power to beam us to the Starbucks in White Rock, so I said thank you (several times) but “no, this is a self-inflicted wound sir.”

Actually, we were doing fine and I don’t know why he suspected otherwise. The sea was in a very sour and raspy mood, but the boat didn’t seem to mind. Hallberg-Rassy for you. Perhaps the tanker captain thought we should be home bathing the children.

Other highlights of the journey? We carried a small bird, struggling to stay airborne, the last 50 miles, only to see itdie when we reached the harbour. A flying fish also landed on the boat, and died.

Oh, and iVane, our wind-steering partner. What a gem! It steered 230 hard miles without even nut rations. I don’t fully understand the genious of iVane, but I do fully appreciate its indomitable – even insouciant – response to provocative seas. I should see if it can do Wx forecasting.

We’ll be here a few days before rounding the SE coast of Sicily an on to Ragusa. I’m sure word has spread amongst the small birds and flying fish that Red Shoes is a rough ride.

Cordially,
brine and matey

From: Robin Anderson
Sent: Monday, May 02, 2011
To: ‘John Curry’

Hi John and team,

Have posted a fuller review of Big Beast rudder and reviewed use with Tiller pilot.

Cheers,
Robin

From: Dale Tournier
Sent: March-30-11
To: Will Curry

Hi Will,

I’ve been sailing all morning dead down wind and the Hydrovane is working very well. It worked straight away without much playing around, I’m surprised how easy it was to get steering the boat. Only about 10-12 knots of wind, I’ll be interested to see how it performed in other conditions.

Cheers Dale.

And later this:

On 2011-04-15
Dale Tournier wrote:

Hi Will, just a progress report. Have had light winds for the last week (400nm) even used hydrovane while flying the assymetrical. It’s now 4:30am and a 18knot westerly has come upon the beam quite quick, Hydrovane is working very well, I still surprised at how easy it is to set. I’ll send you a picture of Hydrovane sailing Freeform under spinnaker.

Cheers, Dale

From: Ariane
Sent: March-18-11
To: Will Curry
Subject: Re: Hydrovane Shaft Replacement

Hi Will

You want to hear a little report about the Hydrovane on the ARC and WorldARC (it will join us also in the ARC Europe). It´s easy to tell. It was the best part we mounted on our boat. The Hydrovane steered us safely through the Atlantic, Pacific, Indian, South-Atlantic and will lead us through the North-Atlantic back to the Mediterranean.

Only when motoring, we used our electric autopilot. We did recommend the Hydrovane to all interested people we met. A safe steering without consuming energy was for us extremely important, as we got our energy only from 6 Solarpanels and the Duogen. We had no Diesel-generator.

Kind regards

Roland, Skipper Ariane

Custom extendable A Bracket – new A bracket opens 40 – 80 degrees:

From: Boat 2050
Sent: March-14-11
To: Will Curry
Subject: hydrovane/watermaker

Hi Will, we love our Hydrovane and just recently moved onto our boat full time. I’m enclosing pictures of our Hydrovane install as I promised months ago.

Second question, we are getting ready to buy a watermaker. We looked at all the watermakers currently on the market, and based on our research, the Echo Tech is the best for our needs.

We will follow up with a phone call later today or tomorrow.

Pat and Matt Tate

From: Manfred Rausch
Sent: March-12-11
To: Will Curry; Valerie Williams
Subject: Little story

Hi Valerie and Will,

Everything is now installed and working. The promised little story (lost or stolen rudder) is attached (follows):

We crossed the Atlantic Ocean and all 29 days our Hydrovane was doing a perfect job under any conditions.

The rudder was taken off and secured at the stern of the boat, after we made the passage from St. Martin to the BVIs. During short trips between the islands we steered by hand. Now we intended to leave Puerto Rico for the Turks and Caicos Islands. The day before, we checked out and prepared our boat for the passage. The rudder of our Hydrovane windvane could not be found, we lost it, or it had been stolen.

The Sunday, I wrote an email to Valerie at Hydrovane.

Monday, I got in contact with Will by phone and email to clear all necessary details. In the years between we bought the unit originally and today the rudder had been improved and the construction was changed, two options were proposed.

Tuesday, we decided to convert to the new technology, that means changing the shaft and use the improved version of the new rudder.

Wednesday, rudder and shaft were shipped from UK to Puerto Rico, via UPS express service – estimated arrival Friday.

Friday 4 pm we were happy to receive the parts in Puerto Rico.

Saturday, two and a half hours work and the new shaft was on its place, the disassembling of the drive unit took the most of the time, not unexpected because aluminum and stainless steel tend to build oxides which do not “slide off” easily. The instructions and advises we were given were very helpful and finally we managed the changeover.

Thank You, Valerie and Will for the quick service, good advice and the personnel support. Again you (Hydrovane team) have shown that you really know about the needs of circumnavigators.

Barbara and Manfred, SY Balimara
Puerto Rico, March 2011

From: Philip Bouscarle [mailto:philip@bouscarle.co.uk]
Sent: Wednesday, February 23, 2011 8:52 AM
To: john@hydrovane.com
Subject: Victoria 34 installation

Hi John,

I have had very good experiences with Hydrovane, having sailed a Wauquiez Centurion 47 from Antigua to the UK via the Azores in heavy weather. So heavy it stripped our rack and pinion autopilot within a few days of setting sail. The Hydrovane worked flawlessly on the crossing and as we were only 2 up, gave us much needed respite from steering.

I am now looking at a Vic 34 and see that you have a picture of a Hydrovane fitted with HE Brackets on the website.

You also seem to indicate you favour an A bracket for strength, especially with the new rudder. Presumably the picture on the website was taken before the new rudder was introduced.

Would you recommend an A bracket for a Victoria 34 now?

With best wishes,
Philip

From: Leif Stubkjær
Sent: Friday, February 18, 2011
To: John Curry
Subject: New “sock”

Dear John.

Last year we purchased a Hydrovane unit for our 39″ sailing yacht. It has now delivered effortless steering for thousands of miles on our voyage from Denmark to Cuba. We are very satisfied with its performance, but the red vindvane nylon “sock” is now giving up to wear. In other words, we need a new one.

Can you supply this as a package sent directly to a marina in Cuba?

Best regards from
Leif Stubkjaer

From: Lauren Buchholz
Sent: Thursday, February 17, 2011
To: Linda
Subject: Parts

Hi, I have a hydrovane that is a few years old now. Firstly, it has been great. We are just starting a multi year trip around the pacific, but she has performed as good if not better than I had hoped.

If there is enough wind to sail the boat well, it steers is great, even with a kite up in many conditions. Now have used it almost the entire way from Seattle down the coast to zihuatanejo, mexico and will be using on the way to the south pacific later in march.

Anyway, while doing some cleaning of the main gear unit, we lost both of the little black plastic screws that hold the cover on. I didn’t see those as spare parts, but are they available? I am heading back to Seattle later this month, so if it possible to get a pair that I can bring back down to the boat, that would be great!

Thanks,

Lauren
S/V Piko

From: Robin Anderson
Sent: Tuesday, February 15, 2011
To: John Curry
Subject: Review of big beast rudder

Hi John and team,

Review of big beast rudder at link here with.

In short I am very pleased with the big beastie.

Odd performance when motoring. If I leave the pin out when motoring the rudder takes a set against the prop/keel wash and the weather helm at the wheel is very heavy. Once locked off however the weight comes off the helm and she holds a good line. With the small rudder the opposite was the case – it needed to be left free or the weight was felt on the wheel.

My only concern is how the big beast will work with a tiller pilot when there is no wind. I have bought a Raymarine SPX5 which should be ideal but perhaps the balance of the big blade with waterflow over it will make the unit have to work hard. Will find out soon enough and let you know.

Prefer not to motor anyway so well done.

Cheers,
Robin

From: Jean Claude Fleuret
Sent: January-31-11
To: Will Curry
Subject: yacht Drisar

Hello Will, hello John,

Il me semble que vous comprenez le français, alors je vais employer ma langue maternelle pour vous écrire, c’est plus facile; de votre côté, n’hésitez pas à me répondre en anglais, je le lis facilement.

Voici une nouvelle navigation terminée; votre régulateur est merveilleux, incroyable d’efficacité par toutes les allures; durant une grande partie, une amie navigatrice qui dispose sur son voilier d’un Windpilot m’a assuré que son régulateur ne barrait pas aussi bien, surtout en ce qui concerne les allures au portant; de plus, elle doit toujours assurer une surveillance pour corriger souvent les trajectoires, choses qui ne se font pas avec un Hydrovane, vraiment fantastique. Bravo pour toute cette ingénierie et toutes les astuces que vous avez mis au point pour obtenir un fini remarquable.

Dans mon cas, sachez que j’ai remplacé le pin de l’immergé par un pin en acier renforcé; après 25’000 milles nautiques, le jeu dans l’immergé est devenu plus important, mais il n’empêche pas son bon fonctionnement.

L’une des deux voiles fournies est complètement usée, c’est pourquoi je vous en commande une nouvelle. Quand j’ai remplacé la voile, j’étais assez fier de voir resplendir ce rouge qui dirige si fidèlement mon voilier Drisar.

Bien cordialement.

JC Fleuret, SY Drisar

Editor’s translation:

It seems to me that you understand French, then I will employ my native tongue to write to you, it is easier; on your side, do not hesitate to answer me in English, I read it easily.

Another voyage completed; your self steering system is marvelous, incredible for its effectiveness in all conditions; a crew member who has a xxxxxxxxx on her boat says that it does not hold the course nearly as well: moreover it requires regular monitoring and adjustments – things that are not done with the Hydrovane, really fantastic. Cheers for the engineering that makes it simple to operate – remarkable.

I did replace the Locking Pin for the Rudder. After 25,000 nautical miles ….. but it did not affect performance. One of the two Vane Covers is completely worn out, hence I am ordering a new one.

When I replace the Vane Cover I am proud to display the red flag which directs my DRISAR so accurately.

JC Fleuret SY Drisar

From: David Colbert
Sent: Thursday, February 10, 2011
To: JEC – Hydrovane
Subject: hydrovane and para-anchors

Hi John

We purchased a hydrovane from you a couple of years ago and have since been sailing the western Pacific and are happy to report that the hydrovane has performed very well.

We also carry a parachute anchor for storm conditions. You will be well aware that setting a parachute anchor off the bow can put a lot of strain on rudders as the boat is forced backwards by the seas. Do you have a recommended procedure for dealing with the hydrovane rudder while using a parachute anchor? In the likely conditions it would be very hard to remove. And has anyone had first hand experience of lying to a parachute anchor in storm conditions with a hydrovane attached to the stern that you are aware of?

Thanks
Dave
___

On Sun, Feb 13, 2011 at 3:52 AM,
John Curry wrote:

Hi Dave

Good to hear from you.

I think the para anchor should keep both your rudders safe. As you know the para anchor is intended to hold the boat relatively in position with a slow drift backwards. Regardless, if the boat is picked up and thrown, as can happen in a storm, the rudder is certainly a concern.

We have never heard from anyone with a Hydrovane using a para anchor in a storm.

The Hydrovane rudder is not the worry – it is indestructible. The vulnerable part is the shaft – which can bend under extreme load. A few years ago we upgraded the shaft to accommodate our bigger rudder. Have yet to see one of the new shafts bend.

Hal Roth’s storm tactic was to keep the boat going forward with a tiny storm sail and if still going too fast a drogue would be deployed to slow it down. He felt the big vulnerability when hove to was to the rudder. That concept is what concerns you … and me.

In my 20,000 plus miles of ocean sailing I have only been in one storm – 40 to 45 knots for 32 hours – mid way between Hawaii and Vancouver. The first point is that it is rare to ever get caught in a storm that merits a para anchor and even at those wind speeds which produced 20 or 25 foot seas I would wonder about the challenges of deploying a para anchor. At near the same time we had friends heading to Alaska that were caught in a storm and did deploy a para anchor. They report an equally awful boat motion with or without it and a risky job in deploying it – not that impressed.

Although in our storm we hoved to with our staysail…… and were completely thrown sideways a few times by big waves – but no damage. If I had to do it again I would consider using that small staysail sheeted hard as a rock with a course of 15 degrees off of dead downwind. If boat speed as a worry I would deploy a drogue off the stern.

Cheers
John
___

From: David Colbert
Sent: Saturday, February 12, 2011
To: John Curry
Subject: Re: hydrovane and para-anchors

Thanks for all that John. It is good to get the benefit of your experiences. I agree with the tactic of sailing off at about 15+ degrees from downwind with a very small amount of sail. I have done it once in 60+ knots and it worked well. However, we do carry the para anchor as a requirement of New Zealand Category One Regulations. You must have either a para anchor or a drogue. We can’t tow a drogue because the Hydrovane is offset and would possibly interfere with any drogue. Therefore we have the para anchor which we have never had to stream in anger and hope never to do so!

My concern for the Hydrovane, as is yours, is the shaft if we do ever have to deploy the para anchor, but I guess that is just something we will find out about…

You may be interested to know that on our last passage from New Caledonia to Australia we were surfing at up to 14 knots in 30 – 35 knots of wind and the Hydrovane is fine.

Dave

From: elinpee mongelli
Sent: Thursday, February 03, 2011
To: John Curry
Subject: Mongell’s

Hello,

Firstly, we are now in New Zealand and have thoroughly tested our Hydrovane.

As you suggested…should we encounter severe winds the vane would touch the Bimini.
When we left Brisbane we had NE winds of 10 knots and less…but still our Hydrovane carried on very nicely. From this we went to a Southerly wind of 35 knots which quickly went to a freezing 50+ wind. At that point the vane did touch…so we have rectified that.

We gave multiple thanks to the Hydrovane as it sailed the boat on beautifully to Noumea.

On leaving New Caledonia we had the rockiest trip from Noumea to Auckland over three days. The boat (and all the other ones out with us) pounded and crashed…just about all the boats arriving at that time had leaks from shrouds – to give you an idea… But, the Hydrovane was fantastic… cannot express how pleased we are.

Unfortunately … we do have electrolysis on the Bearing Cap and cannot figure out why. We have completely isolated the hull from the metal and most times the shaft is out of the water …. the vane is on for passages only. Do you have any ideas?

Thanks in advance
Lorna and Philip

From: Iain Carpenter
Sent: February-01-11
To: Will Curry
Subject: RE: Hydrovane Parts

Hi Will

Incidentally I really do rate my Hydrovane, it sits there all day no sound, no power consumption, no problems happily keeping us on course without complaint….. I rated it No 1 piece of kit for the transatlantic crossing and use it for passage making all the time.

I have told countless people with boats <40ft that they couldn't do better than fit one if they don't already have wind vane steering. Those that can't manage the Hydrovane probably shouldn't be blue water sailing!! With best wishes Iain Iain Carpenter MD FRCP Emeritus Professor Centre for Health Services Studies University of Kent